利用AVL_BOOST软件建立4190系列船用四冲程增压柴油机整机模型，并对柴油机额定工况进行仿真计算，通过柴油机额定工况下的实机实验数据对BOOST模型进行修正，直至仿真模型计算结果与实验数据吻合.利用验证的BOOST仿真模型，结合4190系列中速柴油机的特点，根据柴油机的故障分类对柴油机额定工况下的供油定时、单缸供油量不均匀、活塞环漏气、涡轮增压器效率降低和空冷器冷却效率下降故障进行仿真计算，得出不同故障下柴油机性能参数与热工参数的变化，为柴油机故障的诊断与排除提供一定参考.
Abstract
The whole mathematical model of 4190 series four-stroke turbocharged marine diesel engine is build by using the AVL_BOOST software, and the simulation of the diesel engine rated operating conditions is carried out. The BOOST model is corrected by actual experimental data of diesel engine rated conditions, until the simulation result is consistent with experimental data. Then using the BOOST simulation model validated, combining with the characteristics of the 4190 series of medium-speed diesel engine, fault simulations are carried out at rated conditions for injection timing, single-cylinder fuel supply uneven, piston ring leaking, efficiency of the turbocharger reducing as well as cooling efficiency decreasing of air cooler according to the various fault classification of the diesel engine. The changes of diesel engine performance parameters and thermal parameters are derived in different failure modes, which can provide some reference for diesel engine fault diagnosis and troubleshooting.
关键词
船用四冲程柴油机 /
整机建模 /
故障模拟 /
故障诊断
Key words
vessel /
intake system /
emergency bypass device /
pressure difference /
numerical simulation
{{custom_sec.title}}
{{custom_sec.title}}
{{custom_sec.content}}
参考文献
［1］ 曹汉龙. 柴油机智能化故障诊断技术［M］. 北京：国防工业出版社，2005： 7-8.
［2］周俊杰，邱东，解茂昭，等. 柴油机工作过程数值计算［M］. 大连：大连理工大学出版社，1989：10-14.
［3］王洪锋，余永华，杨建国，等. 基于AVL BOOST软件的柴油机故障仿真研究［J］. 船舶工程，2007，29(S2): 158-162.
WANG Hong-feng, YU Yong-hua, YANG Jian-guo, et al. Diesel engine fault simulation based on AVL BOOST software［J］. Marine Engineering, 2007, 29 (S2): 158-162. (in Chinese)
［4］李国宾，段树林，于洪亮，等. 发动机振动信号特征参数的多重分形研究［J］. 内燃机学报，2008, 26（1）：878-891.
LI Guo-bin, DUAN Shu-lin, YU Hong-liang, et al. Multifractal study of the characteristic parameters of the engine vibration signal ［J］. Transactions of CSICE, 2008, 26 (1) :878-91. (in Chinese)
［5］孙建波，郭晨，魏海军，等. 船用柴油机增压器喘振的计算与特性分析［J］. 大连海事大学学报，2008, 34(1): 28-31.
SUN Jian-bo, GUO Chen, WEI Hai-Jun, et al. Calculation and characteristic analysis on turbocharger surging of marine diesel engine ［J］. Journal of Dalian Maritime University, 2008, 34 (1) : 28 -31. (in Chinese)
［6］罗红英. 柴油机故障仿真计算与分析［J］. 内燃机工程，2004 (3): 58-63.
LUO Hong-ying. Diesel engine fault simulation and analysis ［J］. Engineering of CSICE, 2004 (3): 58-63. (in Chinese)
基金
国家自然科学基金资助项目（51279066）；福建省自然科学基金资助项目（2012J01230）.
PDF(733 KB)
